ELLIS PAINT CO -- 338L073, SHAFT LAC NATIONAL BLUE 340VOC  -- 8010-00N045192
<pre>=====================  Product Identification  =====================

Product ID:338L073, SHAFT LAC NATIONAL BLUE 340VOC
MSDS Date:03/29/1993
FSC:8010
NIIN:00N045192
=== Responsible Party ===
Company Name:ELLIS PAINT CO
Address:3150 E PICO BLVD
City:LOS ANGELES
State:CA
ZIP:90023
Country:US
Info Phone Num:213-261-8114
Emergency Phone Num:800-424-9300(CHEMTREC)
CAGE:04GC9
=== Contractor Identification ===
Company Name:ELLIS PAINT CO
Address:3150 E PICO BLVD
Box:City:LOS ANGELES
State:CA
ZIP:90023
Country:US
Phone:213-261-8114
CAGE:04GC9
Company Name:ELLIS PAINT CO
Address:3150 E PICO BLVD
Box:City:LOS ANGELES
State:CA
ZIP:90023-3683
Country:US
Phone:323-261-8114
CAGE:0RGC9

=============  Composition/Information on Ingredients  =============

Ingred Name:ISOPROPYL ALCOHOL  (SARA III). VP:32 @ 68F.
CAS:67-63-0
RTECS #:NT8050000
Fraction by Wt: <0.5%
OSHA PEL:400 PPM;500 PPM STEL
ACGIH TLV:400 PPM;500 PPM STEL

Ingred Name:ETHANE, 1,1,1-TRICHLORO-; (1,1,1-TRICHLOROETHANE)  (SARA
    III). VP:3 @ 68F.
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 13%
OSHA PEL:350 PPM;450 PPM STEL
ACGIH TLV:350 PPM;450 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1

Ingred Name:1,3-DIOXOLANE; (GLYCOL METHYLENE ETHER)
CAS:646-06-0
RTECS #:JH6760000
Fraction by Wt: <0.5%
OSHA PEL:N/K 
ACGIH TLV:N/K 

Ingred Name:SEC-BUTYL ALCOHOL  (SARA III). VP:12 @ 68F.
CAS:78-92-2
RTECS #:EO1750000
Fraction by Wt: <0.5%
OSHA PEL:100 PPM
ACGIH TLV:100 PPM

Ingred Name:BUTANE, 1,2-EPOXY-; (1,2-BUTYLENE OXIDE)  (SARA III)
CAS:106-88-7
RTECS #:EK3675000
Fraction by Wt: <0.5%
OSHA PEL:N/K 
ACGIH TLV:N/K 
EPA Rpt Qty:1 LB
DOT Rpt Qty:1 LB

Ingred Name:BLUE PIGMENT; (COPPER PHTHALOCYANINE)
CAS:147-14-8
Fraction by Wt: 1%
OSHA PEL:15 MG/M3 (MFR)
ACGIH TLV:10 MG/M3 (MFR)

Ingred Name:SOLVENT NAPHTHA (PETROLEUM) MEDIUM ALIPHATIC; (MINERAL
    SPIRITS). VP:1.1 @ 100F.
CAS:64742-88-7
Fraction by Wt: <5%
OSHA PEL:100 PPM (MFR)
ACGIH TLV:100 PPM (MFR)

Ingred Name:PROPIONIC ACID, 3-ETHOXY-, ETHYL ESTER;
    (ETHYL-3-ETHOXYPROPIONATE). VP:1.1 @ 68F.
CAS:763-69-9
RTECS #:UF3325000
Fraction by Wt: <5%
OSHA PEL:N/K 
ACGIH TLV:50 PPM (MFR)

Ingred Name:TITANIUM OXIDE; (TITANIUM DIOXIDE)
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: <5%
OSHA PEL:10 MG/M3 TDUST
ACGIH TLV:10 MG/M3 TDUST

Ingred Name:CARBON BLACK
CAS:1333-86-4
RTECS #:FF5800000
Fraction by Wt: <0.5%
OSHA PEL:3.5 MG/M3
ACGIH TLV:3.5 MG/M3

Ingred Name:COBALT; (COBALT SALT AS CO)  (SARA III)
CAS:7440-48-4
RTECS #:GF8750000
Fraction by Wt: <0.5%
OSHA PEL:0.05 MG/M3
ACGIH TLV:0.05 MG/M3 DUST

Ingred Name:ZIRCONIUM; (ZIRCO SALT AS ZR)
CAS:7440-67-7
RTECS #:ZH7070000
Fraction by Wt: <0.5%
OSHA PEL:5 MG/M3;10 STEL
ACGIH TLV:5 MG/M3;10 STEL

Ingred Name:VOLATILE ORGANIC COMPOUNDS. %: COATING:2.52 LB/GAL (301
    G/L). MATERIAL:2.26 LB/GAL (271 G/L).
RTECS #:9999999VO
Fraction by Wt: SEE ING

Ingred Name:XYLENE  (SARA III). VP:6.1 @ 68F.
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 2%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:100 PPM;150 PPM STEL
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:2-PENTANONE; (METHYL PROPYL KETONE). VP:28 @ 68F.
CAS:107-87-9
RTECS #:SA7875000
Fraction by Wt: 10%
OSHA PEL:200 PPM;250 PPM STEL
ACGIH TLV:200 PPM;250 PPM STEL

Ingred Name:LIGROINE; (VM&P NAPHTHA). VP:9.8 @ 68F.
CAS:8032-32-4
RTECS #:OI6180000
Fraction by Wt: 5%
OSHA PEL:300 PPM;400 PPM STEL
ACGIH TLV:300 PPM

Ingred Name:TOLUENE  (SARA III). VP:21.8 @ 68F.
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 4%
OSHA PEL:100 PPM;150 PPM STEL
ACGIH TLV:50 PPM, S
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:2-BUTANONE; (METHYL ETHYL KETONE) (MEK)  (SARA III).
    VP:70.9 @ 68F.
CAS:78-93-3
RTECS #:EL6475000
Fraction by Wt: 1%
OSHA PEL:200 PPM;300 PPM STEL
ACGIH TLV:200 PPM;300 PPM STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:SOLVENT NAPHTHA (PETROLEUM), LIGHT ALIPHATIC. VP:41.4 @
    68F.
CAS:64742-89-8
Fraction by Wt: <5%
OSHA PEL:400 PPM (MFR)
ACGIH TLV:400 PPM (MFR)

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:YES  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:YES	 OSHA:NO
Health Hazards Acute and Chronic:INHAL:MAY CAUSE DIZZ, HDCH, NAUS &
    LOSS OF COORD. EYE:MAY CAUSE DISCOMFORT & IRRIT. SKIN:MAY CAUSE
    IRRIT. ABSORPTION MAY CAUSE DERM. INGEST:MAY CAUSE GI IRRIT, NAUS,
    VOMIT & DIARR. ACUTE:MAY CAUSE EYE , NOSE & RESP TRACT IRRIT, HDCH,
    DROW &NAUS. INGEST MAY CAUSE VOMIT & SUBSEQUENT ASPIR OF LIQ INTO
    (EFTS OF OVEREXP)
Explanation of Carcinogenicity:COBALT:IARC MONOGRAPHS ON EVALUATION OF
    CARINOGENIC RISK OF CHEMS TO MAN, VOL 52, PG 363, 1991:GRP 2B.
    ANIMAL: (SUPDAT)
Effects of Overexposure:HLTH HAZ:LUNGS MAY LEAD TO CHEM PNEUM & PULM
    EDEMA. CHRONIC:LONG TERM EXPOS MAY LEAD TO CNS DEPRESS.
    CHLOROCARBON MATLS HAVE PRDCD SENSIT OF MYOCARDIUM TO EPINEPHRINE
    IN LAB ANIMALS & COULD HAVE SIMIL AR EFT IN HUMANS. ADRENOMIMETICS
    (E.G.,EPINEPHRINE) MAY BE CONTRAINDICATED EXCEPT FOR
    LIFE-SUSTAINING USES IN (SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING EYE, SKIN &
    RESPIRATORY DISORDERS MAY BE AGGRAVATED.

=======================  First Aid Measures  =======================

First Aid:INHAL:REMOVE TO FRESH AIR & PROVIDE OXYGEN IF BREATHING IS
    DIFFICULT. EYES:FLUSH IMMEDIATELY W/LARGE AMOUNTS OF WATER FOR AT
    LEAST 15 MINUTES. SKIN:WASH AFFECTED AREAS W/SOAP & WATER. REMOVE
    CONTAMINA TED CLOTHING. INGEST:DO NOT INDUCE VOMITING. IF VOMITING
    OCCURS SPONTANEOUSLY, KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF
    LIQUID INTO LUNGS. GET MEDICAL ATTENTION IMMEDIATELY.

=====================  Fire Fighting Measures  =====================

Flash Point Method:SCC
Flash Point:21.0F,-6.1C
Lower Limits:1%
Upper Limits:15%
Extinguishing Media:FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED PRESSURE DEMAND SCBA &
    FULL PROTECTIVE EQUIPMENT . DO NOT USE DIRECT STREAM OF WATER.
Unusual Fire/Explosion Hazard:FIRE-EXPOSED CNTNRS SHOULD BE COOLED
    W/WATER TO PVNT PRESS BUILD UP WHICH COULD RSLT IN CNTNR RUPTURE.
    THERMAL DECOMP PRODS MAY INCL HCL & PHOSGENE .

==================  Accidental Release Measures  ==================

Spill Release Procedures:REMOVE ALL SOURCES OF IGNITION & PROVIDE
    VENTILATION. LARGE SPILLS MAY BE SCOOPED UP W/NON-SPARKING TOOLS.
    SMALL SPILLS MAY BE PICKED UP W/ABSORBENT MATERIALS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE AWAY FROM HIGH TEMPERATURES,
    SPARKS & OPEN FLAMES. KEEP CONTAINERS TIGHTLY CLOSED. DO NOT TAKE
    INTERNALLY. AVOID PROLONGED CONTACT.
Other Precautions:DO NOT PACKAGE IN ALUMINUM AEROSOL CANS OR W/FINELY
    DIVIDED ALUMINUM/ITS ALLOYS IN AEROSOL CANS. NO SMOKING IN AREA OF
    USE. DO NOT USE IN GEN VICIN OF ARC WELDING, OPEN FLAMES/HOT SURFS.
    HEAT &/OR UV  RADIA MAY CAUSE FORM OF HCL &/OR(SUPDAT)

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:USE NIOSH/MSHA APPROVED SELF-CONTAINED BREATHING
    APPARATUS WHERE VAPOR CONCENTRATION MAY BE ABOVE TLV LIMITS. USE
    NIOSH/MSHA APPROVED RESPIRATORS WHERE VAPOR CONCENTRATION DOES NOT
    EXCEED TLV LIMITS.
Ventilation:ADEQUATE VOLUME & PATTERN TO CONTROL AIRBORNE
    CONCENTRATIONS BELOW EXPOSURE GUIDELINES.
Protective Gloves:CHEMICAL RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKER GOGGLES .
Other Protective Equipment:SAFETY SHOWER & EYE BATH.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING WASHROOM.
    SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
EXPLAN OF CARCIN:PULM FIBROSIS (BLOOD EFTS). EFTS OF OVEREXP:HUMANS
    ACUTELY/CHRONICALLY EXPOS TO CHLOROCARBONS . NOTE:TOLUENE APPEARS
    ON NAVY LIST OF OCCUP CHEM REPRO HAZS. SEEK CONSULTATION FRO M
    APPROP PROFESSIONALS CONCERNING LATEST HAZ LIST INFO & SAFE HNDLG &
    EXPOS INFO . OTHER PREC:PHOSGENE .

==================  Physical/Chemical Properties  ==================

HCC:F3
Boiling Pt:B.P. Text:>165F,>74C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:1 (H*2O=1)
Evaporation Rate &amp; Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:BLUE LIQUID W/MILD ODOR.

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
METALLIC ALUMINUM, ZINC POWDERS & LONG TERM CONTACT W/WATER.
Stability Condition to Avoid:OPEN FLAMES, WELDING ARCS OR OTHER HIGH
    TEMPERATURE SOURCES.
Hazardous Decomposition Products:THERMAL DECOMPOSTION MAY YIELD CARBON
    DIOXIDE, CARBON MONOXIDE, HYDROGEN CHLORIDE & TRACES OF PHOSGENE &
    CHLORINE.

====================  Disposal Considerations  ====================

Waste Disposal Methods:PLACE IN TIGHTLY CLOSED CONTAINERS. INCINERATE
    OR DISPOSE OF I/A/W LOCAL, STATE & FEDERAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.